底板磚胎膜施工方案

1、中國建筑一局（集團）有限公司宿州蘇寧廣場底板磚胎膜施工方案目錄一、編制依據一、編制依據.............................................................................................................................2二、工程概況二、工程概況.......................................

2、......................................................................................2三、施工部署三、施工部署.........................................................................................................................

3、....2四、施工準備四、施工準備.............................................................................................................................24.1技術準備......................................................................

4、.............................................24.2材料準備...................................................................................................................34.3機具準備............................................

5、.......................................................................34.4現場準備...................................................................................................................3五、施工工藝五、施工工藝.............

6、................................................................................................................35.1磚胎膜砌筑...................................................................................................

7、............35.2磚胎膜側邊土體回填...............................................................................................7六、質量保證措施六、質量保證措施...................................................................................

8、..................................76.1基本要求...................................................................................................................76.2質量保證體系.....................................................

9、......................................................86.3磚胎膜質量要求.......................................................................................................8七、安全文明保證措施七、安全文明保證措施...............................

10、..............................................................................97.1安全管理體系...........................................................................................................97.2.文明施工要求和措施...........

11、..................................................................................12中國建筑一局（集團）有限公司宿州蘇寧廣場底板磚胎膜施工方案34.2材料準備1、灰砂磚或水泥磚：規格一致。有出廠證明或試驗單。2、水泥砂漿：采用P.O32.5普通硅酸鹽水泥。中砂，并應過5mm孔徑的篩。砂的含泥量不超過5％。不得含有草根等雜物。4.3機具準備砂漿攪拌機、磅秤

12、、手推車、大鏟、刨錛、托線板、線墜、木折尺、灰槽（鐵或橡膠的）、小水桶、磚夾子、小線、篩子、掃帚、八字靠尺板、鋼筋卡子、鐵抹子等。4.4現場準備1、基槽、砂石地基均已完成，并辦完隱檢手續。2、已放好基礎軸線及邊線；立好皮數桿，并辦完預檢手續。3、根據皮數桿最下面一層磚的標高，拉線檢查基礎墊層、表面標高是否合適，如第一層磚的水平灰縫大于20mm時，應先用細石混凝土找平，嚴禁在砌筑砂漿中摻細石處理或者用砂漿墊平，更不允許砍磚包合子找平。4、

13、常溫施工時，磚塊必須在砌筑前一天澆水濕潤；一般以水浸入磚四邊1.5cm左右為宜。5、砂漿配合比已經試驗確定?，F(xiàn)場準備好砂漿試模。五、施工工藝5.1磚胎膜砌筑本工程基礎筏板、承臺、集水坑等部位側邊采用砌筑磚胎膜的方案。5.1.1施工流程土方開挖→承臺墊層澆筑→測量放線→磚胎膜砌筑→磚模兩側回填→底板碎石褥墊層鋪設→底板墊層澆筑→測量放線→底板磚模砌筑5.1.2磚胎膜砌筑對于非放坡的部分，根據承臺、集水坑的深度確定相應磚胎膜的厚度。對于放坡